查看所有试题
- 精馏塔在操作时由于塔顶冷凝器冷却水用量不足而只能使蒸汽部分冷凝,则馏出液浓度。()A、下降#
B、不动
C、下移
- 采用出口阀门调节离心泵流量时,开大出口阀门扬程()。A、增大
B、不变
C、减小#
D、先增大后减小
- 由乙烯制取二氯乙烷,反应式为C2H4+Cl2ClH2C-CH2Cl。通入反应的乙烯量为600Kg/h,其中乙烯含量为92%(wt%),反应后得到二氯乙烷为1700Kg/h,并测得尾气中乙烯量为40Kg/h,则乙烯的转化率、二氯乙烷的产率及收率分别是(
- 采用出口阀门调节离心泵流量时,开大出口阀门扬程()。A、增大
B、不变
C、减小#
D、先增大后减小
- 有关精馏操作的叙述错误的是()。馏塔精馏段操作线方程为y=0.75x+0.216,则操作回流比为()。A、精馏的实质是多级蒸馏
B、精馏装置的主要设备有:精馏塔、再沸器、冷凝器、回流罐和输送设备等
C、精馏塔以进料板为
- 干燥计算中,湿空气初始性质绝对湿度及相对湿度应取()。A、冬季平均最低值
B、冬季平均最高值
C、夏季平均最高值#
D、夏季平均最低值
- 裂解气多段压缩的优点包括()。螺纹管的外表面可扩展为光管的()倍。A、可节省压缩功#
B、可降低压缩比#
C、可降低排气温度#
D、可简化工艺流程A、1.5~2.5
B、2.2~2.5
C、2.2~2.7#
D、2.5~2.8
- 分离效率降低,且全塔压降增加,其原因及应采取的措施是()。A、它降低了环境温度
B、产生强制对流带走了人体表面的热量#
C、增强了自然对流
D、产生了导热A、塔板受腐蚀,应增加塔釜热负荷
B、筛孔被堵塞,孔径减小,孔
- 载体是固体催化剂的特有成分,下列载体中具有高比表面积的载体是()。A、活性炭#
B、硅藻土
C、氧化镁
D、刚玉
- 可能导致液泛的操作()。A、液体流量过小
B、气体流量太小
C、过量液沫夹带#
D、严重漏夜
- 局部紧急停车的处理原则有()。将加热室安在蒸发室外面的是()蒸发器。A、安全原则#
B、经济原则#
C、因地制宜,区别对待的原则#
D、各系统保温保压保液面A、中央循环管式
B、悬筐式
C、列文式#
D、强制循环式
- 蒸发真空系统的下水封槽的主要用途是()。以下图例,()表示调节阀。A、盛装大气冷凝器下水
B、作为真空系统液封#
C、便于大气冷凝水下水
D、为充分利用空间作为冷却水临时储水槽A、A
B、B
C、C
D、D#
- 目前我国冰醋酸的生产方法主要是()。除了催化剂的活性外,()也是影响固定床反应器开工周期的原因。矿山安全设施的三同时制度是指:矿山建设工程安全设施必须和主体工程()。A、甲醇羰基化方法
B、乙烯氧化法#
C
- 乙烯装置的火炬系统一般由()。用离心泵向高压容器输送液体,现将高压容器改为常压容器,其它条件不变,则该泵输送液体流量(),轴功率()。A、火炬排放系统#
B、气、液分离系统#
C、火炬头系统#
D、火炬气回收系统A
- 精馏塔釜温度指示较实际温度高,会造成()。催化裂化装置中催化剂架桥()。催化剂装填时,不能从高于()处往下倾倒。A、轻组分损失增加
B、塔顶馏出物作为产品不合格#
C、釜液作为产品质量不合格
D、可能造成塔板严
- 裂解气中乙炔浓度较高时,反应器一般可采用()。硝酸生产中氨氧化用催化剂的载体是()。A、单段床绝热
B、多段串联的绝热反应器#
C、等温反应器#
D、等温绝热式反应器串联使用#A、SiO2
B、无#
C、Fe
D、Al2O3
- 已知环氧乙烷合成反应器生产能力为144t/d,年工作时间8000h,按乙烯原料计算,生成环氧乙烷的选择性为71%,通入反应器的乙烯为43720kg/h,下列生产指标正确的是()(原子量:C-12,O-16)新氢中的惰性气体含量大小对加氢
- 乙烯生产工艺中裂解气的分离一般采用()。离心泵在正常运转时,其扬程与升扬高度的大小比较是()。A、深冷分离法#
B、油吸收精馏分离法
C、催化加氢精馏法
D、精馏法A、扬程>升扬高度#
B、扬程=升扬高度
C、扬程
- 通常对气固相放热催化反应而言,下列四种类型的反应器中相对采用较少的类型是()。A、多段绝热式固定床反应器,段间采用间接换热形式
B、多段绝热式固定床反应器,段间采用直接冷激形式
C、沸腾床反应器,反应器中设置
- 某化学反应温度每升高10℃反应速度增加3倍,当温度升高40℃时,反应速度共增()。A、12
B、81#
C、27
- 加氢裂化过程中,()脱氢的反应。蒸发流程效间()不需用泵输送溶液,但不宜处理黏度随浓度变化较明显的溶液。日常生活中,安全使用含氯制剂时需要注意的事项,正确的是以下()。A、也会有#
B、不会有
C、不可能有A、
- 离心泵装置中()的滤网可以阻拦液体中的固体颗粒被吸入而堵塞管道和泵壳。精馏塔釜压升高将导致塔釜温度()。A、吸入管路#
B、排出管路
C、调节管路
D、分支管路A、不变
B、下降
C、升高#
D、无法确定
- 裂解气采用五段压缩时,关于压力对碱洗的影响,下列说法正确的有()。A、提高压力有利于CO2和H2S的吸收#
B、压力高不利于CO2和H2S的吸收
C、压力过高会使裂解气中的重烃露点升高,凝液增加#
D、提高操作压力会增加设备
- 翅片管换热器的翅片应安装在()。下列物质与水或酸接触会产生可燃气体,同时放出高热的是()。α小的一侧#
α大的一侧
管内
管外A、碳化钙(电石)#
B、碳酸钙
C、锌#
D、硝化棉
- 与平推流反应器比较,进行同样的反应过程,全混流反应器所需要的有效体积要()。离心泵在启动前应()出口阀,旋涡泵启动前应()出口阀。晶体的特点是()。A、大#
B、小
C、相同
D、无法确定打开,打开
关闭,打开#
打
- 一台离心泵开动不久,泵入口处的真空度正常,泵出口处的压力表也逐渐降低为零,此时离心泵完全打不出水。发生故障的原因是()。由气体和液体流量过大两种原因共同造成的是()现象A、忘了灌水
B、吸入管路堵塞#
C、压
- 往复泵适应于()。下层塔板的液体漫到上层塔板的现象称为()。大流量且要求流量均匀的场合
介质腐蚀性强的场合
流量较小、压头较高的场合#
投资较小的场合A、液泛#
B、漏液
C、载液